Engine Cooling SystemRepair in Batumi

Cooling system repair in Batumi at PRO SERVICE (Airport Highway 212): we find the cause of overheating or coolant loss and replace the radiator, water pump, thermostat or hoses, or repair the fan. Diagnostics from … GEL, takes 1-2 hours. Overheating puts the head gasket and cylinder head at risk — better not to wait.

Symptoms

• The temperature gauge reads higher than usual, especially in traffic or uphill.
• Coolant level drops, colored drips under the car, a sweet smell.
• The heater blows cold with the engine warm.
• The fan does not switch on, or runs all the time.
• The engine takes long to warm up — often a thermostat stuck open.
• White vapor from the exhaust and sludge under the oil cap — check the head gasket right away.

In Batumi summers, heat plus traffic and mountain climbs are exactly where a weak cooling system shows itself.

How we find the cause

• Pressure test of the system: leaks from the radiator, hoses, pump and heater core become visible.
• Expansion tank cap test — if it does not hold pressure, coolant boils earlier.
• Thermostat, temperature sensor and fan operation checked in live data.
• Water pump inspection: bearing play, leaks from the weep hole.
• If a head gasket is suspected — a combustion gas test of the coolant.

What we repair

• Radiator — replacement; leaking seams or cracked plastic tanks cannot always be repaired.
• Water pump — replacement. If the pump is driven by the timing belt, it makes sense to replace both together.
• Thermostat and temperature sensor — replacement followed by bleeding the system.
• Hoses and clamps — replacing cracked and swollen ones.
• Fan, viscous clutch, relay — diagnostics and repair or replacement.

After any repair we fill coolant to the manufacturer's spec and bleed out air pockets — otherwise the overheating returns.

Price